Auto Mechanic / Technician
විෂයමාලා
Unit Code- යුනිට් අංකය | Unit Title - යුනිට් නම | Modules (Derived from Unit Competencies) - යුනිට් එකට අදාළ මොඩියුල | NVQ Level - යුනිට් එකේ අන්තර්ගතය අදාල වන මට්ටම |
U01 | Maintain & Replace Primary/Auxiliary Batteries | Battery types & identification; Battery inspection & electrolyte service; Terminal cleaning & corrosion removal; Battery testing; MF/AGM battery checking; Charging rate testing; Battery replacement; Backup power connection; Battery disposal | L3 / L4 |
U02 | Maintain & Repair Starting & Charging Systems | Charging system inspection; Alternator output testing; Belt tension adjustment; Alternator dismantling & testing; Alternator reassembly; Starter circuit voltage?drop testing; Starter motor dismantling & repair; Starter motor bench testing; Flywheel ring gear inspection; Starting system safety | L3 / L4 |
U03 | Maintain & Repair Conventional Ignition System | Ignition visual inspection; Primary circuit testing; Ballast resistor & coil testing; Spark plug service; HT cable testing; Ignition timing & dwell adjustment; Distributor repair; Breaker point adjustment; Road?test verification | L3 / L4 |
U04 | Maintain & Repair Electronic Ignition System | Electronic ignition identification; Component mapping; Scanner?based diagnosis; Sensor/actuator testing; ECU/PCM testing; Knock sensor testing; Ignition coil testing; Fault isolation; DTC clearing | L4 |
U05 | Maintain & Repair EFI (Gasoline & Diesel) | Fuel type identification; EFI component mapping; Gasoline EFI diagnosis; Diesel EFI diagnosis; Injector service; Throttle body service; Accelerator pedal module testing; EFI wiring testing; Sensor/relay/fuse service; ECU testing; Fuel pump pressure test; Diesel EDC diagnosis; High?pressure pump inspection; Diesel pre?filter service; Glow plug testing; Emission system service | L4 |
U06 | Maintain & Repair Chassis Electronic Control Units | Electronic suspension diagnosis; Suspension component testing; Suspension calibration; EPS diagnosis; Steering angle sensor alignment; EPS motor testing; Electronic transmission diagnosis; TCM testing; AMT calibration; 4WD/AWD diagnosis; ABS/TCS/ESC/ECB diagnosis; Brake calibration | L4 |
U07 | Maintain & Repair Electrical & Electronic Accessories | Power mirror service; Mirror folding repair; Power shutter diagnosis; Power seat diagnosis; Power door/sliding door repair; Sunroof/convertible roof repair; Defogger service; Power outlet service; BCM accessory diagnosis; Scanner?based accessory calibration | L4 |
U08 | Maintain & Repair Safety, Driver Information & Security Systems | Driver information diagnosis; Cluster repair; Central locking service; Keyless entry diagnosis; Airbag system diagnosis; Immobilizer diagnosis & key programming; Anti?theft system service; ADAS diagnosis; Radar/camera/sensor calibration | L4 |
U09 | Maintain & Repair Lighting, Wiper & Horn Systems | Headlamp diagnosis; Headlamp alignment; Lighting circuit repair; Wiper motor/linkage service; Washer pump/nozzle service; Horn circuit diagnosis; Relay/fuse service; Lighting retrofitting | L3 / L4 |
U10 | Maintain & Repair Climatic Control System | AC visual inspection; AC pressure testing; Compressor clutch/motor testing; HVAC actuator testing; Cabin temperature sensor testing; AC relay/fuse service; Refrigerant leak testing; AC recharging | L4 |
U11 | Install & Maintain In?Car Entertainment & Navigation Systems | Audio installation; Speaker/amplifier testing; Navigation installation; Reverse camera installation; CAN?bus integration; Multimedia diagnosis; Antenna/signal testing | L4 |
U12 | Repair & Maintain Hybrid System & Components | Hybrid system identification; HV safety procedures; HV battery service; Inverter/converter testing; Hybrid motor testing; Regenerative braking diagnosis; Hybrid ECU diagnosis; HV isolation testing | L4 |
U13 | Repair & Maintain Electric Vehicle System & Components | EV HV safety; EV battery pack diagnosis; Battery cooling service; Inverter/controller testing; Traction motor testing; On?board charger diagnosis; DC?DC converter testing; EV charging system diagnosis; Isolation resistance testing; EV CAN?bus diagnosis | L4 |
BU01 | Workplace Communication & Interpersonal Relations | Workplace communication; Customer interaction; Report writing; Team communication | L3 / L4 |
BU02 | Occupational Literacy & Numeracy | Basic mathematics; Electrical calculations; Reading technical manuals; Measurement & units | L3 / L4 |
BU03 | Work in Teams | Team roles; Workshop coordination; Conflict resolution; Collaborative problem solving | L3 / L4 |
BU04 | Occupational Health & Safety | PPE usage; Workshop safety; Chemical handling; Electrical safety; Fire safety; Environmental compliance | L3 / L4 |